EcuFlash Discussion about EcuFlash.
Sponsored by:
Sponsored by:

Non start condition!

 
Old 12-15-2013, 02:53 PM
  #1  
Newb
Thread Starter
 
Join Date: Dec 2013
Location: Hendersonville, NC
Posts: 22
Total Cats: -1
Default Non start condition!

Hello, everyone!
I have a '91 turbo miata with the FM Link ECU.
One day I got in it to go to work and it wouldn't start. When you turn the switch on, the radiator fans come on and the lights in the Link hand controller come on, but the display in the controller never comes on and, of course, the car will not start.
I have traced out and tested all of the grounds going to the ECU, tested all of the power going to the ECU and replaced the coolant temp sensor. All is good but the ECU still doesn't boot up.
I have tested and changed out everything I can think of, to no avail. Anyone have any suggestions?
I even pulled the ECU card and the controller card and examined them for burned traces and/or components. Everything looks good.
Miablo is offline  
Old 12-16-2013, 05:14 PM
  #2  
Newb
Thread Starter
 
Join Date: Dec 2013
Location: Hendersonville, NC
Posts: 22
Total Cats: -1
Default

Today I pulled the ECU out and hooked it up in the white Miata and it booted up when I turned on the key. So, at least now I know it isn't the ECU or the controller cable... or the controller.
I guess that means there is a sensor bad somewhere. I will try putting the white car's ECU in and see what it does next warm day I have.
Miablo is offline  
Old 12-23-2013, 02:43 PM
  #3  
Newb
Thread Starter
 
Join Date: Dec 2013
Location: Hendersonville, NC
Posts: 22
Total Cats: -1
Default

Problem solved.
Miablo is offline  
Old 12-23-2013, 03:49 PM
  #4  
Elite Member
iTrader: (2)
 
fooger03's Avatar
 
Join Date: Jan 2009
Location: Columbus, OH
Posts: 4,158
Total Cats: 201
Default

Dear Miablo,
Have you ever had a car problem and couldn't figure out what the cause/fix was, you could only describe the symptoms? You did a little bit of searching and research using your symptoms and FINALLY you found the thread where someone had the EXACT SAME PROBLEM that you had?

You scroll through the 20 or so posts where people recommend suggestions which don't seem to work for the OP, and then finally you get to the end of the thread and find NOTHING.

Or worse, the OP responds to the thread with simply: "Problem Solved!!!"

Not only is the thread 2 or 3 years old, but the poster isn't an active member of the site, so you can't message him. You simply sit there, staring at your computer screen, blood boiling, and you scream at the top of your lungs:



WHY YOU NO TELL US ANSWER!?

Help out a future Miablo: Please post the solution to your problem.
fooger03 is offline  
Old 12-24-2013, 05:10 PM
  #5  
Newb
Thread Starter
 
Join Date: Dec 2013
Location: Hendersonville, NC
Posts: 22
Total Cats: -1
Default

You are absolutely right, fooger! My apologies.
As I was working my way through sensors, someone suggested (on miata.net) I check the CAS. So, I looked up the pin-out for the CAS cable, then proceeded outside to check said voltages. I discovered there was no +12v on the plug, so I came online and consulted a wiring diagram for the car in order to trace out the source and possible "break" points along the line.
I discovered that the +12v that goes to the CAS harness also goes to the ECU. So, I traced it through the ignition switch (which was good), through the main fuse block (also good) to the main really... which was bad. I replaced it with the relay from my other Miata and, VOILA! The little red devil is alive once more!
If anyone has any questions, please feel free to ask.
Miablo is offline  
Old 12-24-2013, 10:25 PM
  #6  
Elite Member
iTrader: (2)
 
fooger03's Avatar
 
Join Date: Jan 2009
Location: Columbus, OH
Posts: 4,158
Total Cats: 201
Default

Wow, nice job troubleshooting; +props for a very well written answer!
fooger03 is offline  
Old 02-24-2014, 09:40 AM
  #7  
Junior Member
 
Join Date: Jun 2013
Location: Raleigh, NC
Posts: 122
Total Cats: -10
Default

Same symptoms and problem I have. Will be replacing the main relay soon.
ecc3189 is offline  
 
Related Topics
Thread
Thread Starter
Forum
Replies
Last Post
Full_Tilt_Boogie
Build Threads
67
03-16-2019 08:07 PM
nbdooey
Miata parts for sale/trade
9
08-30-2017 09:50 PM
The Gleas
MEGAsquirt
3
10-01-2015 09:30 AM
mx592
Suspension, Brakes, Drivetrain
1
10-01-2015 12:45 AM
shooterschmidty
Engine Performance
8
09-30-2015 10:28 PM


Thread Tools
Search this Thread
Quick Reply: Non start condition!


Archive - Advertising - Cookie Policy - Privacy Statement - Terms of Service

© 2019 MH Sub I, LLC dba Internet Brands

We are a participant in the Amazon Services LLC Associates Program, an affiliate advertising program designed to provide a means for us to earn fees by linking to Amazon.com and affiliated sites.